1991 Mazda B-Series Truck
Only 14 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 14 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 14
- Recalls
- 4
- Investigations
- 2
- Top problem
- —
Too few to rank
Campaigns on file for 1991
Opened by NHTSA
Not enough data
Complaints per year
1991: 14 complaints
View as data table
| Year | Complaints |
|---|---|
| 1990 | 16 |
| 1991 | 14 |
| 1992 | 11 |
| 1993 | 9 |
| 1994 | 126 |
| 1995 | 42 |
| 1996 | 55 |
| 1997 | 52 |
| 1998 | 67 |
| 1999 | 78 |
| 2000 | 58 |
| 2001 | 37 |
| 2002 | 28 |
| 2003 | 21 |
| 2004 | 24 |
| 2005 | 16 |
| 2006 | 11 |
| 2007 | 37 |
| 2008 | 11 |
| 2009 | 4 |
Known problem areas
Only 14 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Seat belts
3 of 14 total reports mention: seat belts, most commonly citing retractor and buckle assembly.
Engine and engine cooling
3 of 14 total reports mention: engine and engine cooling, most commonly citing engine and manifold/header/muffler/tail pipe.
Show complaint excerpts
1991 Mazda b-2600I stalled while driving. *ts when the vehicle stalled it was rear ended by another vehicle. The vehicle was then pushed off the left side of the road into a ditch.
NHTSA ODI report, 2006-07-24
Tl* the contact owns a 1991 Mazda B-Series Truck. The contact stated that exhaust fumes entered the cabin of the vehicle. The vehicle was salvaged and the contact was informed that the failure was due to an incorrectly installed intake manifold.
NHTSA ODI report, 2014-08-14
Service brakes
3 of 14 total reports mention: service brakes, most commonly citing hydraulic.
Seats
2 of 14 total reports mention: seats.
Show complaint excerpts
Driver's seat broke into two in a 10 MPH rear end collision, resulting in injuries.
NHTSA ODI report, 1999-01-20
Left front seat broke into two in a 10 MPH rearend collision.
NHTSA ODI report, 1997-12-18
Electrical system
2 of 14 total reports mention: electrical system, most commonly citing switch and module.
Show complaint excerpts
Vehicle at speed 35MPH, steering column fire, wiring caught on fire, electrical short.
NHTSA ODI report, 1996-06-06
Safety timeline
4 recalls · 2 investigations · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
I
1992-07-29Preliminary evaluationClosed 1992-09-30 Wheel cracking
-
R
1993-01-29Wheels92V139000 The steel spoked wheel assemblies installed as standard equipment or offered as an option on these vehicles were improperly welded during assembly of the wheel rim to disk, which can cause cracks in…
Remedy: Mazda dealers will replace all four wheels without charge.
-
I
1995-06-19Engineering analysisClosed 1996-04-02 Separation of master cylinder
-
R
2006-04-03Exterior lighting06E026000 Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber…
Remedy: Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006. Owners may contact pro-a motors at 323-838-2988.
-
R
2006-07-01Exterior lighting06E049000 Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. Some combination lamps that are…
Remedy: Ck motorsport will notify owners and replace the noncompliant lamps free of charge. The recall began on July 1, 2006. Owners may contact ck motorsport at 1-909-610-7211.
-
R
2009-05-11Exterior lighting09E012000 Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to…
Remedy: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009. Owners may contact sabersport at 1-909-598-7589.
Buy-smart checklist
1991 Mazda B-Series Truck — pre-purchase inspection
Inspect
- Seat belts: 3 reports on file for this year.
- Engine and engine cooling: 3 reports on file for this year.
- Service brakes: 3 reports on file for this year.
Verify these recalls were completed
- Recall 92V139000 · Wheels
- Recall 06E026000 · Exterior lighting
- Recall 06E049000 · Exterior lighting
- Recall 09E012000 · Exterior lighting
Other years of this model
See all years ranked →FAQ
- Is the 1991 Mazda B-Series Truck reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 1991 Mazda B-Series Truck?
- The most-reported component is seat belts, accounting for 21% of complaints on file.
- How many recalls does the 1991 Mazda B-Series Truck have?
- 4 recalls on file for this model year.
Data updated 2026-10-31 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.