2006 GMC Envoy
This year's complaint volume is within 30% of this model's typical year.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
COMPLAINTS PER YEAR
View as data table
| Year | Complaints |
|---|---|
| 1995 | 1 |
| 1996 | 2 |
| 1997 | 1 |
| 1998 | 19 |
| 1999 | 9 |
| 2000 | 22 |
| 2001 | 5 |
| 2002 | 487 |
| 2003 | 392 |
| 2004 | 367 |
| 2005 | 488 |
| 2006 | 351 |
| 2007 | 218 |
| 2008 | 77 |
| 2009 | 17 |
KNOWN PROBLEM AREAS
38% of complaints: fuel system, gasoline — 133 distinct reports on file.
25% of complaints: electrical system — 87 distinct reports on file.
CRASH FIRE INJURYShow complaint excerpts
HAD PROBLEMS WITH THE HEATER'S BLOWER MOTOR NOT BLOWING OR SOMETIMES BLOWING BUT NOT ON EVERY SPEED. LOOKED UP ISSUE ON YOUTUBE AND FOUND MANY VIDEOS OF THE SAME ISSUE AND THE VIDEOS SHOWED THEM HAVING TO REPLACE THE HEATER'S BLOWER MOTOR RESISTER.
NHTSA ODI report, 20190118
TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED THAT BURNING FUMES EMITTED INTO THE VEHICLE AND THE SECURITY SYSTEM LIGHT ILLUMINATED. AS A RESULT, THE ENGINE FAILED TO START UP.
NHTSA ODI report, 20120906
I PARKED MY CAR AND WENT INTO A STORE AND WHEN I CAME OUT I COULD SMELL A BURNING SMELL. MY CAR WOULD NOT UNLOCK FROM THE DRIVERS DOOR AND WHEN I GOT INTO MY CAR I SEEN THAT MY ELECTRICAL PANEL ON THE DRIVERS SIDE BLEW UP. *TR
NHTSA ODI report, 20081224
13% of complaints: exterior lighting — 46 distinct reports on file.
CRASH FIRE INJURYShow complaint excerpts
The contact owns a 2006 GMC Envoy. The contact stated while driving with the low beam headlights engaged, the low beams headlights failed to illuminate, causing a reduced visibility of the roadway.
NHTSA ODI report, 20240903
9% of complaints: fuel/propulsion system — 32 distinct reports on file.
6% of complaints: engine — 20 distinct reports on file.
FIREShow complaint excerpts
RADIATOR AND TRANSMISSION WENT WHILE DRIVING ON A HIGHWAY. MY MECHANIC TOLD ME THE PART THAT FAILED NEVER FAILS AND HE WAS SHOCKED THAT IT DID.
NHTSA ODI report, 20181231
Air bags deflated without warning while driving. Engine misfire for no reason. Had them checked at automove shop.
NHTSA ODI report, 20240719
SAFETY TIMELINE
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GM
Campaign 05V455000 — check if this car was fixed
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND L
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTA
Campaign 05V552000 — check if this car was fixed
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED I
Campaign 06V417000 — check if this car was fixed
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NO 335-1120L-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED D
Remedy: MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON FEBRUARY 16, 2007. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 07E014000 — check if this car was fixed
Fuel Level Gauge System Failure
Driver's Master Power Window Switch
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicle
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300,
Campaign 12V406000 — check if this car was fixed
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascend
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it wil
Campaign 13V248000 — check if this car was fixed
General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles.
Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available.
Campaign 14V404000 — check if this car was fixed
General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles.
Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015.
Campaign 15V599000 — check if this car was fixed
General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab...
Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737.
Campaign 15V519000 — check if this car was fixed
Loss of Headlights
BUY-SMART CHECKLIST
2006 GMC Envoy — pre-purchase inspection
- Test/inspect for fuel system, gasoline issues (133 reports on file for this year).
- Test/inspect for electrical system issues (87 reports on file for this year).
- Test/inspect for exterior lighting issues (46 reports on file for this year).
- Verify recall 05V455000 (steering) has been completed.
- Verify recall 05V552000 (equipment) has been completed.
- Verify recall 06V417000 (air bags) has been completed.
- Verify recall 07E014000 (exterior lighting) has been completed.
- Verify recall 12V406000 (electrical system, visibility) has been completed.
- Verify recall 13V248000 (electrical system, visibility) has been completed.
- Verify recall 14V404000 (visibility) has been completed.
- Verify recall 15V599000 (visibility) has been completed.
- Verify recall 15V519000 (exterior lighting) has been completed.
OTHER YEARS OF THIS MODEL
BEST YEARS
WORST YEARS
FAQ
Is the 2006 GMC Envoy reliable?
Based on NHTSA complaint volume compared to this model's typical year, the 2006 GMC Envoy is rated "typical".
What are the most common problems with the 2006 GMC Envoy?
The most-reported component is fuel system, gasoline, accounting for 38% of complaints on file.
How many recalls does the 2006 GMC Envoy have?
9 recalls on file for this model year.
Data updated 2026-07-11 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.