2001 Chevrolet Silverado 3500
This year had 30% to 100% more complaints than this model's typical year.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
COMPLAINTS PER YEAR
View as data table
| Year | Complaints |
|---|---|
| 1994 | 1 |
| 1996 | 1 |
| 1997 | 61 |
| 1998 | 67 |
| 1999 | 47 |
| 2000 | 80 |
| 2001 | 72 |
| 2002 | 50 |
| 2003 | 42 |
| 2004 | 41 |
| 2005 | 46 |
| 2006 | 52 |
| 2007 | 39 |
| 2008 | 31 |
| 2009 | 10 |
| 2010 | 2 |
| 2011 | 29 |
| 2012 | 23 |
| 2013 | 26 |
| 2014 | 10 |
| 2015 | 52 |
| 2016 | 51 |
| 2017 | 13 |
| 2018 | 19 |
| 2019 | 21 |
| 2020 | 42 |
| 2021 | 39 |
| 2022 | 27 |
| 2023 | 14 |
| 2024 | 49 |
| 2025 | 12 |
| 2026 | 2 |
KNOWN PROBLEM AREAS
Percentages can add to more than 100% -- a complaint can name more than one system.
54% of complaints: service brakes — 39 distinct reports on file, most commonly citing hydraulic and electric.
CRASHShow complaint excerpts
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE ANTI-LOCK BRAKING SYSTEM ACTIVATED WHILE THE CONTACT WAS ATTEMPTING TO PARK THE VEHICLE.
NHTSA ODI report, 20140116
Front right brake overheated.
NHTSA ODI report, 20240909
24% of complaints: engine and engine cooling — 17 distinct reports on file, most commonly citing engine and gasoline.
CRASH FIRE INJURYShow complaint excerpts
CONSUMER COMPLAINED ABOUT AN ENGINE PROBLEM. IT DID NOT MAINTAIN THE THROTTLE. ENGINE WENT INTO NEUTRAL WITHOUT A CAUSE. ALSO, A SUSPENSION PROBLEM DUE TO BOLTS PLACE DIN UPSIDE DOWN POSITION WHICH MIGHT CAUSE VEHICLE TO FLIP.
NHTSA ODI report, 20031128
Also filed under SUSPENSION
CONSUMER PULLED IN FIELD OF FARM AREA THOUGH GRASS. HE TURNED VEHICLE OFF, LEFT A FEW MINUTES, AND A YOUNG GENTLEMAN TOLD HIM THAT VEHICLE WAS ON FIRE. SMOKE WAS COMING FROM FRONT RIGHT TIRE . HE TRIED TO START VEHICLE, AND VEHICLE STOPPED.
NHTSA ODI report, 20010508
10% of complaints: engine — 7 distinct reports on file.
CRASH INJURYShow complaint excerpts
I WAS HIT HEAD ON IN MY 2001 CHEVY DUAL WHEEL TRUCK, BOTH VEHICLES WERE TRAVELING APPROX 40/50MPH, MY TRUCK SHUT OFF ON IMPACT. MY AIR BAGS AND SEAT BELTS DID NOT WORK. I HAD A NECK INJURY AND NEED AN OPERATION. *TR
NHTSA ODI report, 20140820
Also filed under AIR BAGS
While driving engine cuts off intermittently, usually will restart. This is caused by the Crank position sensor. Once replaced, the issue was resolved. This vehicle was NOT covered by NHTSA recall 07U521000.
NHTSA ODI report, 20230724
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 3500. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING IN THE MIDDLE OF THE FREEWAY. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER A FEW ATTEMPTS.
NHTSA ODI report, 20180425
6% of complaints: suspension — 4 distinct reports on file, most commonly citing front.
CRASH6% of complaints: electrical system — 4 distinct reports on file, most commonly citing ignition.
SAFETY TIMELINE
VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE S
Remedy: DEALERS WILL CHANGE THE LOCATION OF A WIRE CONNECTION IN THE UNDERHOOD BUSSED ELECTRICAL CENTER. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN
Campaign 01V220000 — check if this car was fixed
HYDRAULIC PUMP SHAFT FAILURES
HYDRAULIC PUMP FAILRES
CRANK POSITION SENSOR FAILURE - STALL
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURE
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Campaign 06E043000 — check if this car was fixed
BUY-SMART CHECKLIST
2001 Chevrolet Silverado 3500 — pre-purchase inspection
- Test/inspect for service brakes issues (39 reports on file for this year).
- Test/inspect for engine and engine cooling issues (17 reports on file for this year).
- Test/inspect for engine issues (7 reports on file for this year).
- Verify recall 01V220000 (interior lighting) has been completed.
- Verify recall 06E043000 (fuel system, gasoline) has been completed.
OTHER YEARS OF THIS MODEL
BEST YEARS
WORST YEARS
FAQ
Is the 2001 Chevrolet Silverado 3500 reliable?
Based on NHTSA complaint volume compared to this model's typical year, the 2001 Chevrolet Silverado 3500 is rated "worse than typical".
What are the most common problems with the 2001 Chevrolet Silverado 3500?
The most-reported component is service brakes, accounting for 54% of complaints on file.
How many recalls does the 2001 Chevrolet Silverado 3500 have?
2 recalls on file for this model year.
Data updated 2026-09-16 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.