2006 Workhorse W22
Only 8 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 8 complaints on file — too few for a fair verdict. The data below is complete but unranked.
COMPLAINTS PER YEAR
View as data table
| Year | Complaints |
|---|---|
| 2000 | 1 |
| 2001 | 10 |
| 2002 | 67 |
| 2003 | 113 |
| 2004 | 92 |
| 2005 | 21 |
| 2006 | 8 |
| 2007 | 5 |
| 2008 | 4 |
| 2009 | 2 |
| 2011 | 0 |
KNOWN PROBLEM AREAS
Only 8 complaints on file for this model year -- too few to rank by share. Raw counts only, below.
7 of 8 total reports mention: service brakes, hydraulic.
FIREShow complaint excerpts
TL*THE CONTACT OWNS A 2006 WORKHORSE W22. WHEN THE CONTACT DEPRESSED THE BRAKE PEDAL, HE SMELLED A STRONG BURNING ODOR AND NOTICED SMOKE. OCCASIONALLY, HE EXPERIENCES REDUCED BRAKING CAPABILITY.
NHTSA ODI report, 20090521
TL*THE CONTACT OWNS A 2006 WORKHORSE CHASSIS W22. HE RECEIVED RECALL NOTICE# 09V110000 (SERVICE BRAKES, HYDRAULIC) IN MAY OF 2009, AND HE IMMEDIATELY NOTIFIED THE DEALER.
NHTSA ODI report, 20091006
TL*THE CONTACT OWNS A 2006 WORKHORSE W22 CHASSIS. THE CONTACT STATED THAT THE BRAKES FAILED AND THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 09V110000. THE MECHANIC STATED THAT THE ORIGINAL PARTS WERE USED FOR THE RECALL REPAIR.
NHTSA ODI report, 20090717
1 of 8 total reports mentions: service brakes.
Show complaint excerpts
TL* THE CONTACT OWNS A 2006 BOLDER (NA). THE CONTACT STATED THAT THE VEHICLE LOST BRAKING POWER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 9,000.
NHTSA ODI report, 20170117
SAFETY TIMELINE
CERTAIN CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFTS. THE RECALL BEGAN ON MAY 22, 2006. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773.
Campaign 06V148000 — check if this car was fixed
ON CERTAIN MOTOR HOME AND TRUCK CHASSIS EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTUR
Remedy: DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 1, 2006. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773.
Campaign 06V225000 — check if this car was fixed
NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES
Remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
Campaign 09V110000 — check if this car was fixed
BUY-SMART CHECKLIST
2006 Workhorse W22 — pre-purchase inspection
- Test/inspect for service brakes, hydraulic issues (7 reports on file for this year).
- Test/inspect for service brakes issues (1 reports on file for this year).
- Verify recall 06V148000 (steering) has been completed.
- Verify recall 06V225000 (engine and engine cooling) has been completed.
- Verify recall 09V110000 (service brakes, hydraulic) has been completed.
FAQ
Is the 2006 Workhorse W22 reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2006 Workhorse W22?
The most-reported component is service brakes, hydraulic, accounting for 88% of complaints on file.
How many recalls does the 2006 Workhorse W22 have?
3 recalls on file for this model year.
Data updated 2026-07-11 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.