2001 Workhorse W20
Only 2 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 2 complaints on file — too few for a fair verdict. The data below is complete but unranked.
COMPLAINTS PER YEAR
View as data table
| Year | Complaints |
|---|---|
| 2000 | 1 |
| 2001 | 2 |
| 2002 | 6 |
| 2003 | 11 |
| 2004 | 7 |
| 2005 | 3 |
| 2006 | 3 |
| 2007 | 0 |
| 2008 | 0 |
KNOWN PROBLEM AREAS
Only 2 complaints on file for this model year -- too few to rank by share. Raw counts only, below.
1 of 2 total reports mentions: service brakes, hydraulic.
Show complaint excerpts
TL* THE CONTACT OWNS A 2001 WINNEBAGO. THE CONTACT SMELLED SOMETHING BURNING, AND STATED THAT THE BRAKES WERE DRAGGING. THE MANUFACTURER REPLACED THE BRAKE PADS, ROTORS, AND ABS. THE CONTACT LATER RECEIVED A RECALL FOR THE BRAKES.
NHTSA ODI report, 20070319
1 of 2 total reports mentions: electrical system.
Show complaint excerpts
I OWN A 2001 SAFARI TREK, BUILT ON A 17000 GVW WORKHORSE CHASSIS. I WAS TRAVELING AT THE POSTED SPEED LIMIT (70 MPH) IN THE CENTER LANE OF HIGHWAY 99 IN FRESNO CA. MY CRUISE CONTROL DISENGAGED (THE FIRST SIGN) AND I RESET IT.
NHTSA ODI report, 20050914
SAFETY TIMELINE
VEHICLE DESCRIPTION: MOTOR HOME AND COMMERCIAL CHASSIS. THE REAR AXLE U-BOLTS MAY NOT BE TIGHTENED CORRECTLY DUE TO RANDOM FAILURE OF PRODUCTION TOOLING IN THE SPECIFIED TIME SPAN.
Remedy: DEALERS WILL TIGHTEN THE REAR AXLE U-BOLTS. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT
Campaign 01V317000 — check if this car was fixed
OVERHEATING FRONT AND REAR BRAKES
ON CERTAIN MOTORHOME CHASSIS EQUIPPED WITH BOSCH ZOPS, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.
Remedy: DEALERS WILL INSPECT, REPAIR AND REPLACE ACCORDING TO THE PROCEDURE DEVELOPED BY BOSCH (SEE CAMPAIGN 03E064000). THE RECALL BEGAN ON AUGUST 1, 2004. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-677
Campaign 04V084000 — check if this car was fixed
OVERHEATED BRAKE CALIPERS
OVERHEATING DISC BRAKE CALIPER
NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES
Remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
Campaign 09V110000 — check if this car was fixed
BUY-SMART CHECKLIST
2001 Workhorse W20 — pre-purchase inspection
- Test/inspect for service brakes, hydraulic issues (1 reports on file for this year).
- Test/inspect for electrical system issues (1 reports on file for this year).
- Verify recall 01V317000 (suspension) has been completed.
- Verify recall 04V084000 (service brakes, hydraulic) has been completed.
- Verify recall 09V110000 (service brakes, hydraulic) has been completed.
FAQ
Is the 2001 Workhorse W20 reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2001 Workhorse W20?
The most-reported component is service brakes, hydraulic, accounting for 50% of complaints on file.
How many recalls does the 2001 Workhorse W20 have?
3 recalls on file for this model year.
Data updated 2026-07-11 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.