MYRModel Year Report

2004 Volkswagen Beetle

■ Significantly worse — known issue year
2004 Volkswagen Beetle
BUILT 2026-10-10

This year had more than double the complaints of this model's typical year.

This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.

How is this computed?

Complaints
349
Recalls
6

Campaigns on file for 2004

Investigations
1

Opened by NHTSA

Top problem
Power train

45% of complaints

Complaints per year

1998: 171 complaints 1998 1999: 174 complaints 2000: 263 complaints 2001: 203 complaints 2001 2002: 165 complaints 2003: 314 complaints 2004: 349 complaints 2004 349 2005: 261 complaints 2006: 124 complaints 2007: 56 complaints 2007 2008: 60 complaints 2009: 33 complaints 2010: 30 complaints 2010 2012: 65 complaints 2013: 93 complaints 2014: 50 complaints 2014 2015: 83 complaints 2016: 47 complaints 2017: 15 complaints 2017 2018: 17 complaints 2019: 14 complaints
1998: 171 complaints 1998 1999: 174 complaints 2000: 263 complaints 2000 2001: 203 complaints 2002: 165 complaints 2002 2003: 314 complaints 2004: 349 complaints 2004 349 2005: 261 complaints 2006: 124 complaints 2006 2007: 56 complaints 2008: 60 complaints 2008 2009: 33 complaints 2010: 30 complaints 2010 2012: 65 complaints 2013: 93 complaints 2013 2014: 50 complaints 2015: 83 complaints 2015 2016: 47 complaints 2017: 15 complaints 2017 2018: 17 complaints 2019: 14 complaints 2019
1998: 171 complaints 1998 1999: 174 complaints 1999 2000: 263 complaints 2000 2001: 203 complaints 2001 2002: 165 complaints 2002 2003: 314 complaints 2003 2004: 349 complaints 2004 349 2005: 261 complaints 2005 2006: 124 complaints 2006 2007: 56 complaints 2007 2008: 60 complaints 2008 2009: 33 complaints 2009 2010: 30 complaints 2010 2012: 65 complaints 2012 2013: 93 complaints 2013 2014: 50 complaints 2014 2015: 83 complaints 2015 2016: 47 complaints 2016 2017: 15 complaints 2017 2018: 17 complaints 2018 2019: 14 complaints 2019

2004: 349 complaints

View as data table
YearComplaints
1998171
1999174
2000263
2001203
2002165
2003314
2004349
2005261
2006124
200756
200860
200933
201030
201265
201393
201450
201583
201647
201715
201817
201914

Known problem areas

Percentages can add to more than 100% — a complaint can name more than one system.

Power train

45% · 157 reports

Most commonly citing automatic transmission and manual transmission.

CRASHFIRE

Air bags

22% · 76 reports

Most commonly citing sensor/control module and frontal.

CRASHFIREINJURY
Show complaint excerpts

Consumer was involved in an accident where the air bags failed to deploy. The airbag light was on, as well as the check engine and ABS lights.

NHTSA ODI report, 2004-12-14

Also filed under Engine and engine cooling and service brakes, hydraulic

Visibility

18% · 64 reports

Most commonly citing power window devices and controls and motor.

Electrical system

13% · 47 reports

Most commonly citing interior/under dash and fuses and circuit breakers.

FIRE
Show complaint excerpts

Car wouldn't excel while driving suddenly 1 mile from town suddenly traffic slowed from snow storm in town,the vehicle smell was funny black smoked slowly leaked inside the car windows up heard a misfire engine light went on blinked then I heard...

NHTSA ODI report, 2012-12-29

Also filed under Exterior lighting

Engine and engine cooling

6% · 20 reports

Most commonly citing engine and cooling system.

CRASHFIRE
Show complaint excerpts

Tl* the contact owns a 2004 Volkswagen Beetle. The contact was traveling 60 MPH when the vehicle caught on fire. The check engine warning light illuminated seconds prior to the fire.

NHTSA ODI report, 2012-04-19

Safety timeline

6 recalls · 1 investigation · oldest first

To check one car, enter its VIN on the NHTSA recall page. Check a VIN →

  1. ▮
    2004Complaint volume 349 complaints filed for this model year.
  2. R
    2005-02-08Fuel system, diesel04V586000 On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

    Remedy: Dealers will replace the diesel pump. The recall began on February 8, 2005. Owners should contact Volkswagen at 1-800-822-8987.

    Check if this car was fixed →

  3. R
    2007-04-02Service brakes, hydraulic07E023000 Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than DCA7078…

    Remedy: Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during April 2007. Owners can contact cardone at 1-800-777-4780.

    Check if this car was fixed →

  4. R
    2007-04-27Exterior lighting07V063000 On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

    Remedy: Dealers will install the newly designed brake light switch free of charge. The recall began on April 27, 2007, and will be conducted in several staggered mailings through September 21, 2007.…

    Check if this car was fixed →

  5. I
    2008-02-15Preliminary evaluationClosed 2008-04-24 Front air bag crash sensor failure
  6. R
    2008-07-31Air bags08V178000 Volkswagen is recalling 76,900 my 2004-2005 NEW Beetle and my 2003-2005 NEW Beetle convertibles equipped with an advanced (Dual-stage) air bag system. This system may have air bag frontal crash…

    Remedy: Dealers will inspect each vehicle to determine that the specific defect crash sensor is present on one or both sides of the vehicle. All of the defect crash sensors will be replaced free of charge.

    Check if this car was fixed →

  7. R
    2009-05-11Exterior lighting09E012000 Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to…

    Remedy: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009. Owners may contact sabersport at 1-909-598-7589.

    Check if this car was fixed →

  8. R
    2014-05-01Engine and engine cooling14E007000 The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013...

    Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

    Check if this car was fixed →

Buy-smart checklist

2004 Volkswagen Beetle — pre-purchase inspection

Inspect

  • Power train: 157 reports on file for this year.
  • Air bags: 76 reports on file for this year.
  • Visibility: 64 reports on file for this year.

Verify these recalls were completed

  • Recall 04V586000 · Fuel system, diesel
  • Recall 07E023000 · Service brakes, hydraulic
  • Recall 07V063000 · Exterior lighting
  • Recall 08V178000 · Air bags
  • Recall 09E012000 · Exterior lighting
  • Recall 14E007000 · Engine and engine cooling
Inspected by ______________ Date ______________

Other years of this model

See all years ranked →

Best years3 years

Worst years3 years

FAQ

Is the 2004 Volkswagen Beetle reliable?
Based on NHTSA complaint volume compared to this model's typical year, the 2004 Volkswagen Beetle is rated "significantly worse".
What are the most common problems with the 2004 Volkswagen Beetle?
The most-reported component is power train, accounting for 45% of complaints on file.
How many recalls does the 2004 Volkswagen Beetle have?
6 recalls on file for this model year.

Data updated 2026-10-09 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.