1991 Nissan 240SX
Only 9 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 9 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 9
- Recalls
- 1
- Investigations
- 2
- Top problem
- —
Too few to rank
Campaigns on file for 1991
Opened by NHTSA
Not enough data
Complaints per year
1991: 9 complaints
View as data table
| Year | Complaints |
|---|---|
| 1983 | 1 |
| 1987 | 0 |
| 1988 | 0 |
| 1989 | 36 |
| 1990 | 43 |
| 1991 | 9 |
| 1992 | 7 |
| 1993 | 10 |
| 1994 | 2 |
| 1995 | 60 |
| 1996 | 8 |
| 1997 | 6 |
| 1998 | 1 |
Known problem areas
Only 9 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Seat belts
4 of 9 total reports mention: seat belts, most commonly citing retractor and buckle assembly.
Show complaint excerpts
Tl* the contact owns 1991 Nissan 240 sx. The contact stated that the seat belt was inoperable. He contacted a local dealer and the manufacturer and they both diagnosed that the control module would need to be replaced. The vehicle was not repaired.
NHTSA ODI report, 2010-12-28
Both seat belts in the front will not retract. Upon putting the belt on the belt, it will not retract around the front passenger or driver.
NHTSA ODI report, 1997-02-25
The automatic shoulder belt on the driver's side does not go back and forth.
NHTSA ODI report, 1996-11-13
Power train
2 of 9 total reports mention: power train, most commonly citing automatic transmission.
Engine and engine cooling
2 of 9 total reports mention: engine and engine cooling, most commonly citing exhaust system and engine.
Show complaint excerpts
On cold start-up, black smoke emitted from the exhaust.
NHTSA ODI report, 2003-05-04
Warped flywheel caused release bearings/clutch to fail prematurely.
NHTSA ODI report, 1996-02-22
Fuel system, gasoline
1 of 9 total reports mentions: fuel system, gasoline, most commonly citing injectors.
Safety timeline
1 recall · 2 investigations · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
I
1995-03-10Engineering analysisClosed 1995-08-02 Takata seat belt buckle failure
-
R
1995-09-29Seat belts95V103002 The front safety belt buckle release buttons can break. These red plastic release buttons are marked "Press." If a button breaks, pieces can fall into the buckle assembly causing the buckle to…
Remedy: Owners should promptly check the condition and operation of both front safety belt buckles and carefully inspect the red release button for any breaks or cracks. They should ensure that both buckles…
-
I
1999-11-02Recall queryClosed 2000-05-22 Fuel leaks from fuel injectors
Buy-smart checklist
1991 Nissan 240SX — pre-purchase inspection
Inspect
- Seat belts: 4 reports on file for this year.
- Power train: 2 reports on file for this year.
- Engine and engine cooling: 2 reports on file for this year.
Verify these recalls were completed
- Recall 95V103002 · Seat belts
FAQ
- Is the 1991 Nissan 240SX reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 1991 Nissan 240SX?
- The most-reported component is seat belts, accounting for 44% of complaints on file.
- How many recalls does the 1991 Nissan 240SX have?
- 1 recall on file for this model year.
Data updated 2026-10-31 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.