2016 Mercedes-Benz Sprinter 3500
Not enough comparison years on file yet for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
COMPLAINTS PER YEAR
View as data table
| Year | Complaints |
|---|---|
| 2007 | 0 |
| 2008 | 1 |
| 2009 | 1 |
| 2010 | 4 |
| 2011 | 8 |
| 2012 | 20 |
| 2013 | 27 |
| 2014 | 54 |
| 2015 | 21 |
| 2016 | 61 |
| 2017 | 27 |
| 2018 | 9 |
| 2019 | 27 |
| 2020 | 13 |
| 2021 | 9 |
| 2022 | 8 |
| 2023 | 17 |
| 2024 | 3 |
KNOWN PROBLEM AREAS
20% of complaints: service brakes — 12 distinct reports on file.
CRASH FIRE INJURYShow complaint excerpts
WHILE DRIVING ON A MOUNTAIN ROAD THE VEHICLE BEGAN TO SEND FIRE, SMOKE AND STEAM FROM THE MOTOR COMPARTMENT UNDER THE DASH BOARD AND OVER THE WIND SHIELD, CAUSING THE MOTOR TO STOP RUNNING AND SUBSEQUENTLY CAUSING THE BRAKES TO FAIL SENDING MY...
NHTSA ODI report, 20180316
THE VEHICLE HAS EXCESSIVE BRAKE PEDAL FREE-PLAY TRAVEL BEFORE BRAKING OCCURS. ALTHOUGH THE MANUFACTURER'S OWNERS MANUAL WARNS AGAINST PUMPING THE BRAKE PEDAL TO STOP THE VEHICLE, IT IS IMPERATIVE TO DO SO ESPECIALLY IN AN EMERGENCY SITUATION.
NHTSA ODI report, 20160730
20% of complaints: power train — 12 distinct reports on file.
20% of complaints: air bags — 12 distinct reports on file.
CRASH INJURYShow complaint excerpts
TL* THE CONTACT OWNS 2016 MERCEDES-BENZ SPRINTER 3500. WHILE DRIVING 40-45 MPH, THE CONTACT WAS INVOLVED IN A CRASH WITH A SCHOOL BUS TRAVELING NORTH AT 30 MPH. THE AIR BAGS DID NOT DEPLOY.
NHTSA ODI report, 20190930
18% of complaints: electronic stability control (esc) — 11 distinct reports on file.
16% of complaints: vehicle speed control — 10 distinct reports on file.
SAFETY TIMELINE
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vans manufactured April 29, 2015, to December 15, 2015.
Remedy: DVUSA will notify owners, and Mercedes-Benz and Freightliner dealers will replace the incorrect tire pressure label, free of charge. The recall began March 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 16V093000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles manufactured May 31, 2015, to April 30, 2016, and 2015-2016 Freightliner Sprinter 2500 and 3500 vehicles manufactured May 1, 2015,...
Remedy: DVUSA will notify owners, and dealers will install the required crash-pads, free of charge. The recall began on August 11, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 16V351000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured April 1, 2015, to October 31, 2015.
Remedy: DVUSA will notify owners, and dealers will remove the windows and inspect the paintwork, repainting the vehicles as necessary, free of charge. This recall began August 4, 2016. Owners may contact DVUSA customer service at 1-770-705-2070.
Campaign 16V261000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured March 1, 2016, to May 31, 2016.
Remedy: DVUSA will notify owners, and Sprinter dealers will inspect the connecting bolts, tightening them as necessary, free of charge. The recall began on November 18, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 16V670000 — check if this car was fixed
Midwest Automotive Designs, LLC (Midwest) is recalling certain model year 2016 Mercedes Benz Sprinter 2500 and 3500 vehicles manufactured July 1, 2016, to September 30, 2016, equipped with certain left side seat adjusters, model number 486077...
Remedy: Midwest will notify owners, and dealers will replace the left slide track, free of charge. The recall began on December 22, 2016. Owners may contact Midwest customer service at 1-574-522-4878.
Campaign 16V853000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2016 Mercedes-Benz Sprinter 2500 and 3500 and Freightliner Sprinter 2500 and 3500 vans.
Remedy: DVUSA will notify owners, and dealers will install a reinforcement plate and protective bracket around the air bag control unit, free of charge. The recall began on May 26, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 17V093000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles and Freightliner Sprinter 2500 and 3500 vehicles. The bracket for the center support bearing of the drive shaft may not have been properly welded.
Remedy: DVUSA will notify owners and dealers will install three additional rivets to secure the bracket, free of charge. Interim notices informing owners of the safety risk were mailed on May 5, 2017. The recall began on July 7, 2017.
Campaign 17V149000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles equipped with reinforced front axles.
Remedy: DVUSA will notify owners, Freightliner Sprinter and Mercedes-Benz dealers will check and replace the tire label, as necessary, free of charge. The recall began on August 5, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 17V364000 — check if this car was fixed
Midwest Automotive Designs, LLC (Midwest) is recalling certain Custom Vans and Camper Van recreational vehicles built on 2014-2017 Mercedes Benz Sprinter chassis and 2016-2017 RAM Promaster chassis.
Remedy: Midwest will notify owners, and dealers will replace the fire extinguisher with a different brand, free of charge. The recall began on December 11, 2017.
Campaign 17V786000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles. The label on the B-pillar may state a higher maximum vehicle load capacity than the vehicle is designed for.
Remedy: DVUSA will notify owners, and dealers will check the label and replace it if necessary, free of charge. The recall began on December 15, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 17V650000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500/3500 vehicles. The affected vehicles were manufactured without a driveshaft catch strap, allowing a loose driveshaft to strike the fuel tank.
Remedy: DVUSA will notify owners, and dealers will install the missing catch strap for the driveshaft, free of charge. Daimler issued an interim notification to owners on November 17, 2017. The recall began on December 21, 2017.
Campaign 17V592000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Sprinter 2500 and Sprinter 3500 vehicles, equipped with folding seats (sales code S20). The unloaded vehicle weight (UVW) label on these incomplete vehicles may be incorrect.
Remedy: DVUSA will notify owners, and dealers will replace the UVW label and inspect the vehicle to make sure that it is not overloaded, free of charge. The recall began on April 3, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 18V113000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2014-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles.
Remedy: DVUSA will notify owners, and dealers will replace the front passenger air bag module, free of charge. The recall began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 19V004000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles.
Remedy: DVUSA will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall is began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 19V003000 — check if this car was fixed
Rear Wheel Speed Sensor Failure
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 20V663000 — check if this car was fixed
Daimler Vans USA, LLC (DVUSA) is recalling certain 2012-2018 Mercedes Benz Sprinter 3500 and Freightliner Sprinter 3500 vehicles upfitted into campers or recreational vehicles.
Remedy: DVUSA will notify owners, and dealers will replace the rear-wheel speed sensor with a more robust sensor, free of charge. DVUSA issued owners an interim notification on March 10, 2021. Owners may contact DVUSA customer service at 1-877-762-8267.
Campaign 21V042000 — check if this car was fixed
Desiccated Air Bag Inflator Rupture
BUY-SMART CHECKLIST
2016 Mercedes-Benz Sprinter 3500 — pre-purchase inspection
- Test/inspect for service brakes issues (12 reports on file for this year).
- Test/inspect for power train issues (12 reports on file for this year).
- Test/inspect for air bags issues (12 reports on file for this year).
- Verify recall 16V093000 (equipment) has been completed.
- Verify recall 16V351000 (structure) has been completed.
- Verify recall 16V261000 (structure) has been completed.
- Verify recall 16V670000 (seat belts) has been completed.
- Verify recall 16V853000 (seat belts) has been completed.
- Verify recall 17V093000 (air bags) has been completed.
- Verify recall 17V149000 (power train) has been completed.
- Verify recall 17V364000 (equipment) has been completed.
- Verify recall 17V786000 (equipment) has been completed.
- Verify recall 17V650000 (equipment) has been completed.
- Verify recall 17V592000 (power train) has been completed.
- Verify recall 18V113000 (equipment) has been completed.
- Verify recall 19V004000 (air bags) has been completed.
- Verify recall 19V003000 (air bags) has been completed.
- Verify recall 20V663000 (steering) has been completed.
- Verify recall 21V042000 (electronic stability control (esc)) has been completed.
FAQ
Is the 2016 Mercedes-Benz Sprinter 3500 reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2016 Mercedes-Benz Sprinter 3500?
The most-reported component is service brakes, accounting for 20% of complaints on file.
How many recalls does the 2016 Mercedes-Benz Sprinter 3500 have?
16 recalls on file for this model year.
Data updated 2026-07-11 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.