MYRModel Year Report

2002 GMC Envoy XL

○ Not enough data
2002 GMC Envoy XL
RENDERED 2026-11-01T12:45:18.780Z

Not enough comparison years on file yet for a fair verdict.

This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.

How is this computed?

Complaints
70
Recalls
3

Campaigns on file for 2002

Investigations
5

Opened by NHTSA

Top problem
Electrical system

21% of complaints

Complaints per year

2002: 70 complaints 2002 70 2003: 228 complaints 2003 2004: 187 complaints 2004 2006: 109 complaints 2006
2002: 70 complaints 2002 70 2003: 228 complaints 2003 2004: 187 complaints 2004 2006: 109 complaints 2006
2002: 70 complaints 2002 70 2003: 228 complaints 2003 2004: 187 complaints 2004 2006: 109 complaints 2006

2002: 70 complaints

View as data table
YearComplaints
200270
2003228
2004187
2006109

Known problem areas

Percentages can add to more than 100% — a complaint can name more than one system.

Electrical system

21% · 15 reports

Most commonly citing interior/under dash and instrument cluster/panel.

FIRE
Show complaint excerpts

My headlight driver module fuse caught fire and caused a fire in my fuse box in which I had to use a fire extinguisher to put out. The dealership informed me that the fuse got hot and instead of shorting out and blowing the fuse it caught fire.

NHTSA ODI report, 2007-11-02

Exterior lights, interior lights flickering,,,cluster gauges changing state on their own,,,

NHTSA ODI report, 2012-03-09

Also filed under Exterior lighting

Exterior lighting

21% · 15 reports

Most commonly citing tail lights and headlights.

Power train

19% · 13 reports

Most commonly citing automatic transmission and transfer case (4-wheel drive).

Fuel system, gasoline

19% · 13 reports

Most commonly citing tank assembly and filler pipe and cap.

Service brakes

9% · 6 reports

Most commonly citing hydraulic.

Safety timeline

3 recalls · 5 investigations · oldest first

To check one car, enter its VIN on the NHTSA recall page. Check a VIN →

  1. R
    2004-07-06Visibility04V046000 Certain sport utility vehicles have windshield wiper systems that will not turn on, cease operation while in use, fail to turn off/on by themselves (Moisture sensitive wiper system), or have…

    Remedy: Dealers will cover the windshield wiper module vent hole with a patch. Also, the wiper motor, circuit board, and electrical connector will be inspected to signs of water intrusion and/or corrosion…

    Check if this car was fixed →

  2. I
    2004-08-03Engineering analysisClosed 2004-11-04 Brake lamp failure
  3. R
    2004-11-22Exterior lighting04V527000 On certain sport utility vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. If this occurs, the bulb may flicker and eventually become inoperative.

    Remedy: Dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. The recall began on November 22, 2004. Owners should contact Chevrolet at 1-800-630-2438, oldsmobile at…

    Check if this car was fixed →

  4. R
    2006-02-24Latches/locks/linkages05V494000 Certain sport utility vehicles have a rear side closure latch that may not latch or unlatch due to corrosion caused by road splash, such as water and road salt. These vehicles were originally sold…

    Remedy: Dealers will install a seal along the lower part of the rocker panel to prevent intrusion of corrosive material, and inspect the rear side closure latches. Functional latches will be cleaned and…

    Check if this car was fixed →

  5. I
    2007-03-12Preliminary evaluationClosed 2007-07-10 Fuel pump module leaks gasoline
  6. I
    2007-03-13Preliminary evaluationClosed 2007-06-12 Fuel tank leak
  7. I
    2007-07-10Engineering analysisClosed 2008-08-28 Fuel pump module leaks gasoline
  8. I
    2017-04-24Recall queryClosed 2021-03-29 Loss of Headlights

Buy-smart checklist

2002 GMC Envoy XL — pre-purchase inspection

Inspect

  • Electrical system: 15 reports on file for this year.
  • Exterior lighting: 15 reports on file for this year.
  • Power train: 13 reports on file for this year.

Verify these recalls were completed

  • Recall 04V046000 · Visibility
  • Recall 04V527000 · Exterior lighting
  • Recall 05V494000 · Latches/locks/linkages
Inspected by ______________ Date ______________

FAQ

Is the 2002 GMC Envoy XL reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2002 GMC Envoy XL?
The most-reported component is electrical system, accounting for 21% of complaints on file.
How many recalls does the 2002 GMC Envoy XL have?
3 recalls on file for this model year.

Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.