2009 Ford F-650 SD
Only 1 complaint on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 1 complaint on file — too few for a fair verdict. The data below is complete but unranked.
COMPLAINTS PER YEAR
View as data table
| Year | Complaints |
|---|---|
| 2004 | 10 |
| 2005 | 6 |
| 2006 | 3 |
| 2007 | 5 |
| 2008 | 2 |
| 2009 | 1 |
| 2010 | 0 |
| 2011 | 1 |
| 2012 | 0 |
| 2013 | 0 |
| 2015 | 1 |
| 2016 | 3 |
| 2018 | 0 |
| 2019 | 4 |
| 2021 | 1 |
| 2023 | 2 |
| 2025 | 4 |
| 2026 | 1 |
KNOWN PROBLEM AREAS
Only 1 complaint on file for this model year -- too few to rank by share. Raw counts only, below.
1 of 1 total report mentions: service brakes.
Show complaint excerpts
TL* THE CONTACT OWNS A 2009 FORD F-650 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKES FAILED TO RESPOND. THE CONTACT HAD TO MAKE A SHARP LEFT TURN TO AVOID CRASHING INTO A VEHICLE.
NHTSA ODI report, 20170209
SAFETY TIMELINE
FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.
Remedy: FORD IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, OR FORD AT 1-800-343-5338 (FLEET OW
Campaign 08V428000 — check if this car was fixed
FORD IS RECALLING MODEL YEARS 2009 F-650 AND F-750 TRUCKS. THE CHASSIS WIRE HARNESS MAY HAVE BEEN ASSEMBLED WITHOUT A CONNECTOR SEAL IF THIS SEAL IS MISSING, THE CONNECTOR TERMINALS MAY CORRODE AFFE
Remedy: DEALERS WILL INSPECT THE CONNECTOR AND REPAIR THE MAIN AND REAR CHASSIS WIRE HARNESS IF NECESSARY. A MISSING SEAL WILL BE REPLACED AND ELECTRICAL GREASE APPLIED TO PREVENT FUTURE CORROSION. THE SAFE
Campaign 09V476000 — check if this car was fixed
FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE
Remedy: FORD IS WORKING WITH CATERPILLAR TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 8, 2010. OWNERS MAY CONTACT CA
Campaign 10V398000 — check if this car was fixed
BUY-SMART CHECKLIST
2009 Ford F-650 SD — pre-purchase inspection
- Test/inspect for service brakes issues (1 reports on file for this year).
- Verify recall 08V428000 (engine and engine cooling) has been completed.
- Verify recall 09V476000 (exterior lighting) has been completed.
- Verify recall 10V398000 (engine and engine cooling) has been completed.
FAQ
Is the 2009 Ford F-650 SD reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2009 Ford F-650 SD?
The most-reported component is service brakes, accounting for 100% of complaints on file.
How many recalls does the 2009 Ford F-650 SD have?
3 recalls on file for this model year.
Data updated 2026-07-11 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.