2007 Ford F-650 SD
Only 5 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 5 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 5
- Recalls
- 1
- Investigations
- 0
- Top problem
- —
Too few to rank
Campaigns on file for 2007
None on file
Not enough data
Complaints per year
2007: 5 complaints
View as data table
| Year | Complaints |
|---|---|
| 2004 | 10 |
| 2005 | 6 |
| 2006 | 3 |
| 2007 | 5 |
| 2008 | 2 |
| 2009 | 1 |
| 2010 | 0 |
| 2011 | 1 |
| 2012 | 0 |
| 2013 | 0 |
| 2015 | 1 |
| 2016 | 3 |
| 2018 | 0 |
| 2019 | 4 |
| 2021 | 1 |
| 2023 | 2 |
| 2025 | 4 |
| 2026 | 1 |
Known problem areas
Only 5 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Electrical system
2 of 5 total reports mention: electrical system, most commonly citing 12v/24v/48v battery.
Show complaint excerpts
Tl*the contact owns a 2007 Ford f-650 superduty. The contact stated that an electrical fire ignited in the battery compartment. The wiring within the ECM melted down which caused the fire. The fire was put out with an extinguisher.
NHTSA ODI report, 2010-09-08
Tl*the contact owns a 2007 Ford F650. While driving 65 MPH during fair weather conditions the check engine light came on and shut off. The vehicle continued to function normally.
NHTSA ODI report, 2010-04-07
Service brakes
1 of 5 total reports mentions: service brakes.
Show complaint excerpts
Tl* the contact owns a 2007 Ford F-650 SD. While driving 70 MPH, the vehicle failed to accelerate when the accelerator pedal was depressed. In addition, the anti-brake system warning light illuminated.
NHTSA ODI report, 2016-07-18
Power train
1 of 5 total reports mentions: power train.
Show complaint excerpts
Tl* the contact owns a 2007 Ford f-650. The contact stated that while driving 35 MPH, the axle seized without warning. The contact was able to maintain control of the vehicle. The vehicle was not taken to the dealer.
NHTSA ODI report, 2012-03-26
Fuel system, diesel
1 of 5 total reports mentions: fuel system, diesel.
Show complaint excerpts
Fuel tank defect. 2007 Ford F650 xlt super duty truck. VIN # it has come to our attention that numerous truck of this description have had replacement of fuel tanks that have a design flaw.
NHTSA ODI report, 2009-07-27
Safety timeline
1 recall · 0 investigations · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
R
2007-06-12Power train07V238000 On certain trucks built with dana rear axles, the rear axle may have a housing that was built using steel that was thinner than specified.
Remedy: Dealers will replace the axle free of charge. The recall began on June 12, 2007. Owners may contact Ford at 1-800-248-0186.
Buy-smart checklist
2007 Ford F-650 SD — pre-purchase inspection
Inspect
- Electrical system: 2 reports on file for this year.
- Service brakes: 1 report on file for this year.
- Power train: 1 report on file for this year.
Verify these recalls were completed
- Recall 07V238000 · Power train
FAQ
- Is the 2007 Ford F-650 SD reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 2007 Ford F-650 SD?
- The most-reported component is electrical system, accounting for 40% of complaints on file.
- How many recalls does the 2007 Ford F-650 SD have?
- 1 recall on file for this model year.
Data updated 2026-10-31 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.