Is the 2001 Ford E-450 reliable?

There isn't enough NHTSA complaint data on file yet to give this model year a verdict.

What are the most common problems with the 2001 Ford E-450?

The most-reported component is tires, accounting for 44% of complaints on file.

How many recalls does the 2001 Ford E-450 have?

2 recalls on file for this model year.

2001 Ford E-450

○ Not enough data

2001 Ford E-450
RENDERED 2026-11-01T13:35:17.339Z

Only 16 complaints on file — too few for a fair verdict.

This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.

Only 16 complaints on file — too few for a fair verdict. The data below is complete but unranked.

How is this computed?

Complaints: 16
Recalls: 2
Investigations: 3
Top problem: —

Complaints per year

2001: 16 complaints

View as data table

Year	Complaints
1992	0
1993	4
1994	0
1995	0
1996	1
1997	18
1998	5
1999	73
2000	42
2001	16
2002	13
2003	18
2004	27
2005	34
2006	20
2007	12
2008	6
2009	2
2010	5
2011	7
2012	4
2013	12
2014	5
2015	6
2016	17
2017	11
2018	5
2019	5
2021	27
2022	13
2023	2
2024	4
2025	2
2026	2
2027	0

Known problem areas

Only 16 complaints on file for this model year — too few to rank by share. Raw counts only, below.

Tires

7 of 16 total reports mention: tires, most commonly citing tread/belt.

Show complaint excerpts

I have a 2001 jayco 33' class c motor home on a Ford E-450 v-10 chassis. I was traveling on hi I 5 south about 45 miles from sacramento, at 65 MPH when the right rear dual tires blew out.

NHTSA ODI report, 2003-09-20

Firestone steeltex LT22575R16 tread seperation. Tire pres:75PSI, speed 65, temp:80F, road surface: smooth highway,. This is also the third tire failure on this rv. ( At work our Ford SUV has had three tire failures just like my rv)

NHTSA ODI report, 2003-05-23

Suspension

4 of 16 total reports mention: suspension, most commonly citing rear and coil springs.

Show complaint excerpts

We believe this motor home was sold to us with dealership knowing of axle problem, causing rv unable to have wheel alignment corrected. Front rear axle has slipped causing driving hazard.

NHTSA ODI report, 2002-08-23

Body design is too large for E450 van cutaway, brakes can not handle weight. Stopping distance is impaired. Vehicle is unstable in turns and crashs. Brakes last 20,000 miles to 30,000 miles, tires the same.

NHTSA ODI report, 2001-08-13

Also filed under Service brakes, hydraulic

During t wo trips on interstate highways we encountered winds from 10 to 30 MPH. On these occasions I found it necessary to slow down to 40 to 50 MPH speed in order to control motor home.

NHTSA ODI report, 2001-07-23

Engine and engine cooling

3 of 16 total reports mention: engine and engine cooling, most commonly citing engine.

Service brakes

2 of 16 total reports mention: service brakes, most commonly citing hydraulic.

Air bags

1 of 16 total reports mentions: air bags.

Show complaint excerpts

The contact owns a 2001 Ford E-450. The contact stated while driving 35 MPH, the air bag warning light was illuminated. The contact stated while restarting the vehicle, the front driverâs side air bag deployed independently.

NHTSA ODI report, 2021-10-25

Safety timeline

2 recalls · 3 investigations · oldest first

To check one car, enter its VIN on the NHTSA recall page. Check a VIN →

I
2002-08-19Engineering analysisClosed 2003-08-22 Rapid tire deflation
I
2005-03-22Engineering analysisClosed 2006-08-02 Engine compartment fires
R

2006-08-07Vehicle speed control06V286000 On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.

Remedy: Dealers will install a fused wiring harness into the speed control system free of charge. The recall began on August 7, 2006. Owners may contact Ford at 1-866-436-7332. (Note: also see recalls…

Check if this car was fixed →
R

2009-10-27Vehicle speed control09V399000 Ford is recalling model years 1995-2003 Windstar, 2000-2003 Excursion diesel, 1993-1997 and 1999-2003 F-250 SD through f-550 sd diesel, 1992-2003 E-150 through e-550, 1995-2002 Explorer, 1997 and…

Remedy: Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 Windstar vehicles with a leaking scds, dealers will also inspect the ABS control module…

Check if this car was fixed →
I
2009-12-07Preliminary evaluationClosed 2010-04-21 HVAC Switch Failures

Buy-smart checklist

2001 Ford E-450 — pre-purchase inspection

Inspect

Tires: 7 reports on file for this year.
Suspension: 4 reports on file for this year.
Engine and engine cooling: 3 reports on file for this year.

Verify these recalls were completed

Recall 06V286000 · Vehicle speed control
Recall 09V399000 · Vehicle speed control

FAQ

Is the 2001 Ford E-450 reliable?: There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2001 Ford E-450?: The most-reported component is tires, accounting for 44% of complaints on file.
How many recalls does the 2001 Ford E-450 have?: 2 recalls on file for this model year.

Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.