MYRModel Year Report

2006 Dodge Sprinter 3500

○ Not enough data
2006 Dodge Sprinter 3500
RENDERED 2026-11-01T13:33:51.629Z

Only 24 complaints on file — too few for a fair verdict.

This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.

Only 24 complaints on file — too few for a fair verdict. The data below is complete but unranked.

How is this computed?

Complaints
24

Too few to rank

Recalls
3

Campaigns on file for 2006

Investigations
1

Opened by NHTSA

Top problem
—

Not enough data

Complaints per year

2004: 2 complaints 2004 2005: 6 complaints 2005 2006: 24 complaints 2006 24 2007: 15 complaints 2007 2008: 39 complaints 2008 2009: 3 complaints 2009 2012: 2 complaints 2012
2004: 2 complaints 2004 2005: 6 complaints 2005 2006: 24 complaints 2006 24 2007: 15 complaints 2007 2008: 39 complaints 2008 2009: 3 complaints 2009 2012: 2 complaints 2012
2004: 2 complaints 2004 2005: 6 complaints 2005 2006: 24 complaints 2006 24 2007: 15 complaints 2007 2008: 39 complaints 2008 2009: 3 complaints 2009 2012: 2 complaints 2012

2006: 24 complaints

View as data table
YearComplaints
20010
20020
20030
20042
20056
200624
200715
200839
20093
20122

Known problem areas

Only 24 complaints on file for this model year — too few to rank by share. Raw counts only, below.

Engine and engine cooling

11 of 24 total reports mention: engine and engine cooling, most commonly citing engine and gas recirculation valve (egr valve).

Show complaint excerpts

2006 Dodge Sprinter 3500 turbo resonator failures. My wife and I purchased the above unit in the form of a winnebago view. On our first trip we had to cross a small mountain pass in the shenandhoas.

NHTSA ODI report, 2008-06-24

Repeated failure of turbo resonator on Dodge Sprinter 3500 / winnabago view resulting in sudden loss of 90% of power. Part cracks open causing loss of turbo pressure.

NHTSA ODI report, 2008-06-20

Engine

7 of 24 total reports mention: engine.

Show complaint excerpts

Crankshaft position sensor faulty, check engine light comes on upon startup.

NHTSA ODI report, 2018-11-18

Entire mercedes diesel sprinter engine failed completely and will need a new engine. Possible cause is cracked piston or stuck injector.

NHTSA ODI report, 2018-07-30

Tl* the contact owns a 2006 Dodge Sprinter 3500. The contact stated that the check engine warning indicator illuminated and there was a random failure in which a limp mode occurred and caused a drastic reduction in speed.

NHTSA ODI report, 2017-12-14

Electrical system

6 of 24 total reports mention: electrical system, most commonly citing 12v/24v/48v battery.

FIRE
Show complaint excerpts

While driving, on highway saw smoke coming from right side of dash, pulled over, flames observed, used fire extinguisher to put out fire under dash. Entire wiring loom for dash and engine were destroyed.

NHTSA ODI report, 2012-06-18

Also filed under Exterior lighting

The contact owns a 2006. Dodge Sprinter 3500.

NHTSA ODI report, 2024-03-27

Also filed under Service brakes, hydraulic

Service brakes

4 of 24 total reports mention: service brakes, most commonly citing hydraulic.

Exterior lighting

3 of 24 total reports mention: exterior lighting.

FIRE

Safety timeline

3 recalls · 1 investigation · oldest first

To check one car, enter its VIN on the NHTSA recall page. Check a VIN →

  1. R
    2009-02-16Steering08V339000 Sprinter is recalling 10 my 2001-2006 Dodge and freightliner 2500 and 3500 vehicles. The welding seam between the bracket and steering column of affected spare parts does not meet design…

    Remedy: Dealers will inspect and replace the steering columns free of charge. The recall is expected to begin on or before February 16, 2009. Owners may contact sprinter at 843-695-5057.

    Check if this car was fixed →

  2. R
    2015-01-13Equipment adaptive/mobility14V706000 Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles...

    Remedy: Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge.

    Check if this car was fixed →

  3. R
    2017-07-27Electrical system, service brakes, hydraulic16V833000 Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006.

    Remedy: DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017.

    Check if this car was fixed →

  4. I
    2021-09-17Engineering analysisOpen Desiccated Air Bag Inflator Rupture

Buy-smart checklist

2006 Dodge Sprinter 3500 — pre-purchase inspection

Inspect

  • Engine and engine cooling: 11 reports on file for this year.
  • Engine: 7 reports on file for this year.
  • Electrical system: 6 reports on file for this year.

Verify these recalls were completed

  • Recall 08V339000 · Steering
  • Recall 14V706000 · Equipment adaptive/mobility
  • Recall 16V833000 · Electrical system, service brakes, hydraulic
Inspected by ______________ Date ______________

FAQ

Is the 2006 Dodge Sprinter 3500 reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2006 Dodge Sprinter 3500?
The most-reported component is engine and engine cooling, accounting for 46% of complaints on file.
How many recalls does the 2006 Dodge Sprinter 3500 have?
3 recalls on file for this model year.

Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.