MYRModel Year Report

2004 Dodge Sprinter 2500

○ Not enough data
2004 Dodge Sprinter 2500
RENDERED 2026-11-01T15:51:12.805Z

Only 12 complaints on file — too few for a fair verdict.

This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.

Only 12 complaints on file — too few for a fair verdict. The data below is complete but unranked.

How is this computed?

Complaints
12

Too few to rank

Recalls
3

Campaigns on file for 2004

Investigations
0

None on file

Top problem
—

Not enough data

Complaints per year

2001: 1 complaint 2001 2002: 0 complaints 2003: 5 complaints 2004: 12 complaints 2004 12 2005: 21 complaints 2006: 34 complaints 2007: 24 complaints 2007 2008: 53 complaints 2009: 3 complaints 2009 2013: 2 complaints
2001: 1 complaint 2001 2002: 0 complaints 2002 2003: 5 complaints 2003 2004: 12 complaints 2004 12 2005: 21 complaints 2005 2006: 34 complaints 2006 2007: 24 complaints 2007 2008: 53 complaints 2008 2009: 3 complaints 2009 2013: 2 complaints 2013
2001: 1 complaint 2001 2002: 0 complaints 2002 2003: 5 complaints 2003 2004: 12 complaints 2004 12 2005: 21 complaints 2005 2006: 34 complaints 2006 2007: 24 complaints 2007 2008: 53 complaints 2008 2009: 3 complaints 2009 2013: 2 complaints 2013

2004: 12 complaints

View as data table
YearComplaints
20011
20020
20035
200412
200521
200634
200724
200853
20093
20132

Known problem areas

Only 12 complaints on file for this model year — too few to rank by share. Raw counts only, below.

Electrical system

5 of 12 total reports mention: electrical system, most commonly citing ignition.

Show complaint excerpts

The Dodge dealer did the T21 emission recall on 12/08/2017. Eversince this recall service my vehicle has been rendered in-operable with two problems. (1) the battery dies overnight. I have already replaced to new battery with same problem.

NHTSA ODI report, 2018-04-05

Engine

3 of 12 total reports mention: engine.

Engine and engine cooling

3 of 12 total reports mention: engine and engine cooling, most commonly citing gas recirculation valve (egr valve) and diesel.

Show complaint excerpts

Tl* the contact owns a 2004 Dodge Sprinter 2500. The contact stated that the head lamp sensor turned white abnormally, causing limited illumination when driving at night.

NHTSA ODI report, 2012-03-22

Also filed under Exterior lighting

Pn/ 07551201, resonator, failure 3 time in 60,000 miles, lost power.

NHTSA ODI report, 2011-09-24

Also filed under Power train

Power train

2 of 12 total reports mention: power train.

Electronic stability control (esc)

2 of 12 total reports mention: electronic stability control (esc).

Show complaint excerpts

I did the T21 recall update to the PCM and have had check engine light on, then it died and had it towed to the greatest sprinter mechanics in my area. This was after the dealership cleared codes the first time my check engine light came on.

NHTSA ODI report, 2018-07-14

Received t-21 recall notice for 2004 Sprinter 2500. Took to dealership we were sent to by Dodge (Fiat). Dealership did the required software upgrade to the ECU - result was that the entire electrical system is trashed.

NHTSA ODI report, 2018-05-15

Safety timeline

3 recalls · 0 investigations · oldest first

To check one car, enter its VIN on the NHTSA recall page. Check a VIN →

  1. R
    2007-12-17Interior lighting07V299000 On certain trucks equipped with rear air conditioning system, the interior lamp is equipped with an 18W lamp and a scattering lens. In extremely hot and humid conditions, the combination of heat…

    Remedy: Dealers will replace the rear interior lamps free of charge with a modified version which is not subject to the impacts of heat and humidity. The recall began on December 17, 2007. Owners may…

    Check if this car was fixed →

  2. R
    2009-02-16Steering08V339000 Sprinter is recalling 10 my 2001-2006 Dodge and freightliner 2500 and 3500 vehicles. The welding seam between the bracket and steering column of affected spare parts does not meet design…

    Remedy: Dealers will inspect and replace the steering columns free of charge. The recall is expected to begin on or before February 16, 2009. Owners may contact sprinter at 843-695-5057.

    Check if this car was fixed →

  3. R
    2017-07-27Electrical system, service brakes, hydraulic16V833000 Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006.

    Remedy: DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017.

    Check if this car was fixed →

Buy-smart checklist

2004 Dodge Sprinter 2500 — pre-purchase inspection

Inspect

  • Electrical system: 5 reports on file for this year.
  • Engine: 3 reports on file for this year.
  • Engine and engine cooling: 3 reports on file for this year.

Verify these recalls were completed

  • Recall 07V299000 · Interior lighting
  • Recall 08V339000 · Steering
  • Recall 16V833000 · Electrical system, service brakes, hydraulic
Inspected by ______________ Date ______________

FAQ

Is the 2004 Dodge Sprinter 2500 reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2004 Dodge Sprinter 2500?
The most-reported component is electrical system, accounting for 42% of complaints on file.
How many recalls does the 2004 Dodge Sprinter 2500 have?
3 recalls on file for this model year.

Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.