2004 Chevrolet SSR
Only 28 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 28 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 28
- Recalls
- 0
- Investigations
- 1
- Top problem
- —
Too few to rank
None on file
Opened by NHTSA
Not enough data
Complaints per year
2004: 28 complaints
View as data table
| Year | Complaints |
|---|---|
| 2003 | 10 |
| 2004 | 28 |
| 2005 | 31 |
| 2006 | 5 |
Known problem areas
Only 28 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Electrical system
9 of 28 total reports mention: electrical system, most commonly citing instrument cluster/panel.
Show complaint excerpts
Was going to go to the store and when I turned on the ignition every thing was coming on,the lights,dash all lite up ,I heard the fuel pump and I turned the ignition further to start it and nothing. No click,no turning over,nothing.
NHTSA ODI report, 2020-08-16
My vehicle has only 11,656 miles, less than that when I submitted to dealer for non-functioning gauges due to stepper-motor issues.
NHTSA ODI report, 2019-11-22
Also filed under Air bags
Tl* the contact owns a 2004 Chevrolet SSR. The contact stated that upon inspection, the speedometer failed to operate with no warnings. The contact also mentioned that the temperature and oil pressure gauges had failed.
NHTSA ODI report, 2013-09-23
Structure
8 of 28 total reports mention: structure, most commonly citing hinge and attachments and door.
Show complaint excerpts
Truck comes with flimsy hood support, not strong enough to support weight of hood. Fell on my back.
NHTSA ODI report, 2004-08-10
2004 Chevrolet SSR: hood prop failure. The flimsy hood prop holding the gigantic SSR hood is bent. I have purchased an aluminum hood prop to use instead of the faulty factory thin prop. Many have failed and hoods have fallen all the way closed.
NHTSA ODI report, 2004-08-12
Vehicle: 2004 Chevrolet SSR problem: flimsy hood prop rod and a very heavy hood. The rod slipped and the hood fell. Luckily no one was injured, but could easily have been.
NHTSA ODI report, 2004-08-10
Latches/locks/linkages
7 of 28 total reports mention: latches/locks/linkages, most commonly citing latch.
Engine and engine cooling
3 of 28 total reports mention: engine and engine cooling, most commonly citing exhaust system and fan.
Vehicle speed control
2 of 28 total reports mention: vehicle speed control, most commonly citing cruise control.
Safety timeline
No recalls on file for this model year.
0 recalls · 1 investigation · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
I
2017-04-24Recall queryClosed 2021-03-29 Loss of Headlights
Buy-smart checklist
2004 Chevrolet SSR — pre-purchase inspection
Inspect
- Electrical system: 9 reports on file for this year.
- Structure: 8 reports on file for this year.
- Latches/locks/linkages: 7 reports on file for this year.
FAQ
- Is the 2004 Chevrolet SSR reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 2004 Chevrolet SSR?
- The most-reported component is electrical system, accounting for 32% of complaints on file.
- How many recalls does the 2004 Chevrolet SSR have?
- No recalls are on file for this model year.
Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.