2004 Chevrolet S10
Only 21 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 21 complaints on file — too few for a fair verdict. The data below is complete but unranked.
COMPLAINTS PER YEAR
View as data table
| Year | Complaints |
|---|---|
| 1981 | 1 |
| 1982 | 2 |
| 1983 | 7 |
| 1984 | 8 |
| 1985 | 11 |
| 1986 | 22 |
| 1987 | 27 |
| 1988 | 37 |
| 1989 | 48 |
| 1990 | 29 |
| 1991 | 174 |
| 1992 | 180 |
| 1993 | 233 |
| 1994 | 963 |
| 1995 | 910 |
| 1996 | 665 |
| 1997 | 469 |
| 1998 | 613 |
| 1999 | 231 |
| 2000 | 471 |
| 2001 | 307 |
| 2002 | 213 |
| 2003 | 178 |
| 2004 | 21 |
| 2005 | 0 |
| 2006 | 1 |
| 2007 | 0 |
| 2016 | 1 |
| 2017 | 1 |
| 2018 | 3 |
KNOWN PROBLEM AREAS
Only 21 complaints on file for this model year -- too few to rank by share. Raw counts only, below.
3 of 21 total reports mention: electrical system.
FIREShow complaint excerpts
CHEVY S-10 QUAD CAB CAUGHT ON FIRE DUE TO ELECTRICAL MALFUNCTION; PASSENGER SEAT WAS ADJUSTED (ELECTRIC SEAT WITH HEAT) SMELLED SMOKE AND PARKED VEHICLE TOOK KEYS AND EXITED VEHICLE WITH PASSENGER.
NHTSA ODI report, 20100416
TL* THE CONTACT OWNS A 2004 CHEVROLET S-10. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WITHOUT WARNING. THE CONTACT WOULD HAVE TO REMOVE AND REINSERT THE FUSE IN ORDER TO BE ABLE TO RESTART THE VEHICLE.
NHTSA ODI report, 20121003
2 of 21 total reports mention: visibility.
Show complaint excerpts
WHILE DRIVING IN THE RAIN THE WINDSHIELD WIPERS WOULD WORK INTERMITTENTLY. *AK
NHTSA ODI report, 20031015
2 of 21 total reports mention: service brakes, hydraulic.
2 of 21 total reports mention: air bags.
Show complaint excerpts
THE SERVICE AIR BAGS IS STUCK ON ALSO THE SERVICE BRAKE SYSTEM WONT GO OFF.
NHTSA ODI report, 20201229
THE AIRBAG LIGHT CONTINUE TO BLINK OFF AND ON.
NHTSA ODI report, 20180802
1 of 21 total reports mentions: visibility.
SAFETY TIMELINE
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JUNE 4, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Campaign 04V132000 — check if this car was fixed
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE RE
Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 — check if this car was fixed
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONF
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 — check if this car was fixed
BUY-SMART CHECKLIST
2004 Chevrolet S10 — pre-purchase inspection
- Test/inspect for electrical system issues (3 reports on file for this year).
- Test/inspect for visibility issues (2 reports on file for this year).
- Test/inspect for service brakes, hydraulic issues (2 reports on file for this year).
- Verify recall 04V132000 (equipment) has been completed.
- Verify recall 06E065000 (exterior lighting) has been completed.
- Verify recall 09E025000 (exterior lighting) has been completed.
OTHER YEARS OF THIS MODEL
BEST YEARS
WORST YEARS
FAQ
Is the 2004 Chevrolet S10 reliable?
There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
What are the most common problems with the 2004 Chevrolet S10?
The most-reported component is electrical system, accounting for 14% of complaints on file.
How many recalls does the 2004 Chevrolet S10 have?
3 recalls on file for this model year.
Data updated 2026-07-11 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.