2020 Chevrolet Express
Only 17 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 17 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 17
- Recalls
- 1
- Investigations
- 0
- Top problem
- —
Too few to rank
Campaigns on file for 2020
None on file
Not enough data
Complaints per year
2020: 17 complaints
View as data table
| Year | Complaints |
|---|---|
| 1995 | 1 |
| 1996 | 15 |
| 1997 | 29 |
| 1998 | 23 |
| 1999 | 68 |
| 2000 | 84 |
| 2001 | 45 |
| 2002 | 55 |
| 2003 | 58 |
| 2004 | 21 |
| 2005 | 23 |
| 2006 | 12 |
| 2007 | 18 |
| 2008 | 14 |
| 2009 | 10 |
| 2010 | 15 |
| 2011 | 12 |
| 2012 | 13 |
| 2013 | 22 |
| 2014 | 14 |
| 2015 | 8 |
| 2016 | 15 |
| 2017 | 21 |
| 2018 | 11 |
| 2019 | 8 |
| 2020 | 17 |
| 2021 | 13 |
| 2022 | 4 |
| 2023 | 2 |
| 2024 | 1 |
| 2025 | 0 |
| 2026 | 0 |
Known problem areas
Only 17 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Power train
9 of 17 total reports mention: power train.
Show complaint excerpts
Transmission valve
NHTSA ODI report, 2025-09-11
Improper shift and hard jerking downshifts Which has been a continuous problem since September 22
NHTSA ODI report, 2024-04-19
Transmission needs to be replaced at 70k miles and I have had all scheduled service maintenance done. Vehicle jerks hard when shifting gears.
NHTSA ODI report, 2024-02-13
Engine
3 of 17 total reports mention: engine.
Show complaint excerpts
The vehicle is experiencing an under-chassis manufacturing wiring harness restriction (Connector X185) that was installed too tightly from the factory, dropping the 5-volt reference power circuit down to 0 volts under load.
NHTSA ODI report, 2026-09-24
Also filed under Electrical system and fuel/propulsion system
Electrical system
3 of 17 total reports mention: electrical system.
Show complaint excerpts
The contact owns a 2021 Jayco Redhawk. The contact stated that while inspecting underneath the RV the plumbing hoses and lines as well electrical wires, fuel line from the propane tank, and fuel line from the generator was just lying on the frame.
NHTSA ODI report, 2021-09-21
Also filed under Structure
Structure
3 of 17 total reports mention: structure, most commonly citing body and frame and members.
Service brakes
2 of 17 total reports mention: service brakes.
Show complaint excerpts
After purchasing a used vehicle 2020 model, and after setting in owner's garage for two weeks, the vehicle was driven at slow speed thru two intersections after a complete stop.
NHTSA ODI report, 2022-05-26
Safety timeline
1 recall · 0 investigations · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
R
2021-03-22Tires21V115000 General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado...
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021.
Buy-smart checklist
2020 Chevrolet Express — pre-purchase inspection
Inspect
- Power train: 9 reports on file for this year.
- Engine: 3 reports on file for this year.
- Electrical system: 3 reports on file for this year.
Verify these recalls were completed
- Recall 21V115000 · Tires
FAQ
- Is the 2020 Chevrolet Express reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 2020 Chevrolet Express?
- The most-reported component is power train, accounting for 53% of complaints on file.
- How many recalls does the 2020 Chevrolet Express have?
- 1 recall on file for this model year.
Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.