2002 Chevrolet Express 3500
Only 3 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 3 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 3
- Recalls
- 1
- Investigations
- 0
- Top problem
- —
Too few to rank
Campaigns on file for 2002
None on file
Not enough data
Complaints per year
2002: 3 complaints
View as data table
| Year | Complaints |
|---|---|
| 1997 | 2 |
| 1998 | 3 |
| 1999 | 4 |
| 2000 | 4 |
| 2001 | 11 |
| 2002 | 3 |
| 2003 | 12 |
| 2004 | 16 |
| 2005 | 17 |
| 2006 | 15 |
| 2007 | 11 |
| 2008 | 11 |
| 2009 | 9 |
| 2010 | 4 |
| 2012 | 5 |
| 2013 | 1 |
| 2014 | 1 |
| 2019 | 2 |
| 2021 | 1 |
| 2024 | 2 |
Known problem areas
Only 3 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Suspension
1 of 3 total reports mentions: suspension.
Show complaint excerpts
2002 Chevrolet Express 3500. Consumer writes in regards to broken drivers side spring leaf. *ld the consumer stated after a pothole broke the spring leave, it was discovered that spring leaf was incorrectly installed by the factory.
NHTSA ODI report, 2021-02-11
Engine and engine cooling
1 of 3 total reports mentions: engine and engine cooling, most commonly citing diesel.
Show complaint excerpts
2002 Express 3500 6.5 diesel van has started intermittent stalling at highway speeds 60 MPH mid 09/2006. No trouble codes locked in memory.
NHTSA ODI report, 2006-11-06
Engine
1 of 3 total reports mentions: engine.
Show complaint excerpts
Tl* the contact owns a 2002 Chevrolet express cutaway G3500. The contact stated that the vehicle stalled without warning. The contact was able to coast onto the shoulder and restart the vehicle.
NHTSA ODI report, 2012-08-24
Safety timeline
1 recall · 0 investigations · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
R
2007-11-08Equipment07E088000 Certain honeywell fram racing brand HP4 and HP8 oil filters that were manufactured from May 25, 2006, through September 14, 2007, and sold for use as replacement equipment for vehicles list above.…
Remedy: Honeywell will replace the affected oil filters free of charge. The recall began during November 2007. Owners can contact fram customer service toll-free at 1-800-890-2075.
Buy-smart checklist
2002 Chevrolet Express 3500 — pre-purchase inspection
Inspect
- Suspension: 1 report on file for this year.
- Engine and engine cooling: 1 report on file for this year.
- Engine: 1 report on file for this year.
Verify these recalls were completed
- Recall 07E088000 · Equipment
FAQ
- Is the 2002 Chevrolet Express 3500 reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 2002 Chevrolet Express 3500?
- The most-reported component is suspension, accounting for 33% of complaints on file.
- How many recalls does the 2002 Chevrolet Express 3500 have?
- 1 recall on file for this model year.
Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.