2001 Chevrolet Express 3500
Only 11 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 11 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 11
- Recalls
- 1
- Investigations
- 0
- Top problem
- —
Too few to rank
Campaigns on file for 2001
None on file
Not enough data
Complaints per year
2001: 11 complaints
View as data table
| Year | Complaints |
|---|---|
| 1997 | 2 |
| 1998 | 3 |
| 1999 | 4 |
| 2000 | 4 |
| 2001 | 11 |
| 2002 | 3 |
| 2003 | 12 |
| 2004 | 16 |
| 2005 | 17 |
| 2006 | 15 |
| 2007 | 11 |
| 2008 | 11 |
| 2009 | 9 |
| 2010 | 4 |
| 2012 | 5 |
| 2013 | 1 |
| 2014 | 1 |
| 2019 | 2 |
| 2021 | 1 |
| 2024 | 2 |
Known problem areas
Only 11 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Tires
3 of 11 total reports mention: tires, most commonly citing tread/belt and sidewall.
Show complaint excerpts
Tl* the contact owns a 2001 Chevrolet Express 3500 equipped with dextero DHT2 tires, size: LT245/75R/16 (Na). While traveling at highway speeds, the rear passenger tire experienced a blow out.
NHTSA ODI report, 2017-11-28
Service brakes
2 of 11 total reports mention: service brakes, most commonly citing hydraulic.
Engine
2 of 11 total reports mention: engine.
Show complaint excerpts
The rear main seal, front harmonic seal and power steering pump shaft seal are leaking. The vehicle has 96,000 miles on it. This should not be. I took it to a shop last week to have problem fixed. Need help very expensive.
NHTSA ODI report, 2016-05-17
Also filed under Steering
Engine and engine cooling
2 of 11 total reports mention: engine and engine cooling, most commonly citing engine.
Structure
1 of 11 total reports mentions: structure, most commonly citing bumpers.
Show complaint excerpts
Dt*: the contact stated the reinforcement to the front bumper was severely rusted. The service dealer and manufacturer were contacted. Updated 9/13/2006 - the service dealer replaced the reinforcement bar which was under warranty.
NHTSA ODI report, 2006-08-15
Safety timeline
1 recall · 0 investigations · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
R
2007-11-08Equipment07E088000 Certain honeywell fram racing brand HP4 and HP8 oil filters that were manufactured from May 25, 2006, through September 14, 2007, and sold for use as replacement equipment for vehicles list above.…
Remedy: Honeywell will replace the affected oil filters free of charge. The recall began during November 2007. Owners can contact fram customer service toll-free at 1-800-890-2075.
Buy-smart checklist
2001 Chevrolet Express 3500 — pre-purchase inspection
Inspect
- Tires: 3 reports on file for this year.
- Service brakes: 2 reports on file for this year.
- Engine: 2 reports on file for this year.
Verify these recalls were completed
- Recall 07E088000 · Equipment
FAQ
- Is the 2001 Chevrolet Express 3500 reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 2001 Chevrolet Express 3500?
- The most-reported component is tires, accounting for 27% of complaints on file.
- How many recalls does the 2001 Chevrolet Express 3500 have?
- 1 recall on file for this model year.
Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.