1991 Chevrolet C20
Only 6 complaints on file — too few for a fair verdict.
This verdict reflects complaint volume compared to this model's typical year. Recalls and safety issues below apply regardless of the verdict — always check them.
Only 6 complaints on file — too few for a fair verdict. The data below is complete but unranked.
- Complaints
- 6
- Recalls
- 1
- Investigations
- 3
- Top problem
- —
Too few to rank
Campaigns on file for 1991
Opened by NHTSA
Not enough data
Complaints per year
1991: 6 complaints
View as data table
| Year | Complaints |
|---|---|
| 1980 | 1 |
| 1981 | 1 |
| 1982 | 1 |
| 1983 | 1 |
| 1984 | 4 |
| 1985 | 2 |
| 1986 | 0 |
| 1987 | 3 |
| 1988 | 3 |
| 1989 | 1 |
| 1990 | 5 |
| 1991 | 6 |
| 1992 | 2 |
| 1993 | 16 |
| 1994 | 12 |
| 1995 | 14 |
| 1996 | 0 |
| 1997 | 2 |
| 1998 | 0 |
| 2000 | 0 |
| 2001 | 0 |
Known problem areas
Only 6 complaints on file for this model year — too few to rank by share. Raw counts only, below.
Latches/locks/linkages
2 of 6 total reports mention: latches/locks/linkages, most commonly citing latch.
Show complaint excerpts
The drivers door stricker bolt is breaking and the door will not shut properly or latch. Please describe. Tt
NHTSA ODI report, 1995-08-15
Wheels
1 of 6 total reports mentions: wheels, most commonly citing lugs/nuts/bolts/studs.
Seat belts
1 of 6 total reports mentions: seat belts, most commonly citing buckle assembly.
Show complaint excerpts
The seat belt buckle failed.
NHTSA ODI report, 1997-06-27
Fuel system, gasoline
1 of 6 total reports mentions: fuel system, gasoline, most commonly citing mounting.
Show complaint excerpts
Made u-turn; heard rubbing sound; checked underneath; bolt/strap closest to engine came loose from frame; gas tank dropped to ground; could have caused fire.
NHTSA ODI report, 1995-01-12
Engine and engine cooling
1 of 6 total reports mentions: engine and engine cooling.
Show complaint excerpts
1991 Chevrolet c-20 had engine trouble and then began to smoke. Consumer then discovered that the engine compartment was on fire. *kb there was a trail of oil on the pavement prior to the fire. Ohio traffic crash report # 10-0019-90.
NHTSA ODI report, 2008-02-14
Safety timeline
1 recall · 3 investigations · oldest first
To check one car, enter its VIN on the NHTSA recall page. Check a VIN →
-
I
1992-12-08Engineering analysisClosed 1995-03-09 Fuel system integrity
-
R
1993-03-13Power train93V016000 Unanticipated heat in the transmission can force the transmission fluid out of the vent tube.
Remedy: Install a longer transmission vent hose routed to the left side of the engine compartment of the vehicle.
-
I
1993-10-08Preliminary evaluationClosed 1994-02-10 Fuel tank support failure
-
I
1994-07-29Engineering analysisClosed 1996-07-31 Engine compartment fires
Buy-smart checklist
1991 Chevrolet C20 — pre-purchase inspection
Inspect
- Latches/locks/linkages: 2 reports on file for this year.
- Wheels: 1 report on file for this year.
- Seat belts: 1 report on file for this year.
Verify these recalls were completed
- Recall 93V016000 · Power train
FAQ
- Is the 1991 Chevrolet C20 reliable?
- There isn't enough NHTSA complaint data on file yet to give this model year a verdict.
- What are the most common problems with the 1991 Chevrolet C20?
- The most-reported component is latches/locks/linkages, accounting for 33% of complaints on file.
- How many recalls does the 1991 Chevrolet C20 have?
- 1 recall on file for this model year.
Data updated 2026-11-01 · Complaints are unverified owner reports filed with NHTSA, not independently verified defects. Methodology.