1988 Blue Bird TC2000

I 19890213 — PE (closed 19890509)

HEADLIGHT RETAINING RING

I 19890706 — PE (closed 19891116)

CRACKED BRAKE DRUMS

R 19900328 — fuel system, diesel

THE DIESEL FUEL FILTER SEPARATOR IS LOCATED TOO CLOSE TO THE CHASSIS FRAME CROSS MEMBER WHICH COULD DEFORM AND DISLODGE THE BOWL OF THE SEPARATOR IN AN ACCIDENT.

Remedy: RELOCATE FUEL FILTER - SEPARATOR TO ELIMINATE INTERFERENCE WITH CROSSMEMBER IN ANY CRASH.

Campaign 90V011000 — check if this car was fixed

R 19900515 — service brakes, hydraulic

FRONT AXLE ASSEMBLIES MAY CONTAIN CRACKED BRAKE DRUMS DUE TO IMPROPER FIT BETWEEN THE WHEEL HUBS AND THE BRAKE DRUMS.

Remedy: REPLACE DEFECTIVE BRAKE DRUMS.

Campaign 89V202000 — check if this car was fixed

R 19900601 — steering

LOCK PINS IN STEERING WHEEL AND HUB ASSEMBLY MY SHEAR OFF, ALLOWING STEERING WHEEL TO SPIN.

Remedy: REPAIR USING A POSITIVE LOCKING METHOD.

Campaign 90V099000 — check if this car was fixed

R 19901217 — exterior lighting

UNDERSIZED CRIMP ON WIRE FROM HEADLIGHT SWITCH TO DIMMER SWITCH CREATES ELECTRICAL RESISTANCE AND CAN CAUSE A SHORT IN THE HEADLIGHT WIRING SYSTEM.

Remedy: REPLACE DIMMER SWITCH WITH NEW 14 GAUGE WIRE WITH PROPERLY CRIMPED CONNECTIONS.

Campaign 91V014000 — check if this car was fixed

R 19920806 — electrical system

A 150 AMP CIRCUIT BREAKER, OPTION 4362, HAS BEEN WIRED IN PARALLEL WITH A STANDARD EQUIPMENT CIRCUIT, THEREBY NOT PROVIDING THE REQUIRED PROTECTION.

Remedy: THE STANDARD EQUIPMENT CIRCUIT MUST BE REMOVED.

Campaign 92V115000 — check if this car was fixed

R 19930317 — structure

PASSENGERS CLOTHING CAN UNKNOWINGLY BECOME CAUGHT IN THE HANDRAILS AT BUS DOORS WHEN EXITING THE BUS.

Remedy: REPLACE OR REPOSITION THE HANDRAILS TO STOP CLOTHING FROM BECOMING CAUGHT.

Campaign 93V032000 — check if this car was fixed

I 19930512 — PE (closed 19930831)

DOOR LATCH SYSTEMS

R 19950630 — structure

PASSENGERS CLOTHING CAN UNKNOWINGLY BECOME CAUGHT IN THE HANDRAILS AT BUS DOORS WHEN EXITING THE BUS.

Remedy: DEALERS WILL INSTALL A SET SCREW TO THE METAL CLAMP WHICH RETAINS THE INTERMEDIATE HANDRAIL. A HIGH IMPACT MOLDED PLASTIC "CLAM SHELL" WILL BE PLACED OVER EACH END OF THE INTERMEDIATE HANDRAIL COMPLET

Campaign 95V090000 — check if this car was fixed

R 19950719 — structure

THESE UNITS ARE EQUIPPED WITH A COUNTER WEIGHT ASSEMBLY MADE UP OF 300 POUNDS OF 1/4" PLATE STEEL WELDED TOGETHER AND BOLTED BETWEEN THE FRAME RAILS IN THE REAR OVERHANG JUST FORWARD OF THE REAR BUMPE

Remedy: DEALERS WILL INSTALL A MECHANICAL RETAINING DEVICE WHICH CLAMPS THE PLATES TOGETHER AND FASTENED WITH THREADED FASTENERS. BUS OWNERS WILL HAVE THE OPTION OF REPAIRING THEIR OWN VEHICLES.

Campaign 95V136000 — check if this car was fixed

R 19960821 — structure

PASSENGER'S CLOTHING CAN UNKNOWINGLY BECOME CAUGHT IN THE FORWARD HANDRAILS AT BUS DOORS WHEN EXITING THE BUS.

Remedy: OWNERS WILL BE DIRECTED TO REMOVE ALL FORWARD HANDRAILS. PROVISIONS WILL BE MADE FOR THOSE OWNERS OPERATING IN STATES WHICH MANDATE A FORWARD HANDRAIL THAT A REPLACEMENT HANDRAIL WILL BE PROVIDED.

Campaign 96V073000 — check if this car was fixed

R 19980310 — fuel system, gasoline

VEHICLE DESCRIPTION: FRONT AND REAR ENGINE SCHOOL BUSES EQUIPPED WITH 60 GALLON SIDE MOUNTED FUEL TANK BARRIERS. THESE BUSES DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGR

Remedy: BLUE BIRD WILL SHIP INSTRUCTIONS AND MODIFICATION KITS TO THE OWNERS OF THESE BUSES.

Campaign 97V197000 — check if this car was fixed

R 19990729 — seats

VEHICLE DESCRIPTION: SCHOOL BUSES. THE WALL SIDE ATTACHING BOLTS FOR SOME OF THE PASSENGER SEATS MAY HAVE BEEN INSTALLED TOO CLOSE TO THE EDGE OF THE SEAT LEDGE AND IN THE WRONG ATTACHING HOLE RESUL

Remedy: BLUE BIRD WILL FURNISH TO DISTRIBUTORS AND OWNERS, PARTS AND INSTRUCTIONS NECESSARY TO STRENGTHEN THE PASSENGER SEAT ATTACHMENT AT THE WALL SIDE.

Campaign 99V018000 — check if this car was fixed